All-in-One Silk Fibroin Sponge as the Vitrification Cryodevice of Rat Pancreatic Islets and the VEGF-Embedded Scaffold for Subrenal Transplantation.

Islet transplantation is a promising option for the clinical treatment of insulin-dependent diabetes, but a reliable islet cryopreservation/transplantation protocol should be established to overcome the donor shortage. The current study reports that a silk fibroin (SF) sponge disk can be used as a cryodevice for vitrification of large quantity pancreatic islets and the scaffold for subsequent subrenal transplantation in a rat model. The marginal islet mass (550 islet equivalents [IEQs]) on an SF sponge disk was vitrified-warmed and transplanted beneath the kidney capsule of a streptozotocin-induced diabetic rat with or without vascular endothelial growth factor (VEGF). Subrenal transplantation (no scaffold) of 550 IEQ fresh islets and post-warm islets vitrified on a nylon mesh device resulted in achieving euglycemia of recipient rats at 60% and 0%, respectively. Transplantation of 550 IEQ islets vitrified-warmed on an SF sponge disk failed to achieve euglycemia of recipient rats (0%), but the VEGF inclusion in the SF sponge disk contributed to acquiring the euglycemic recipients (33%). All cured recipient rats regained hyperglycemia after nephrectomy, and the histopathologic analysis exhibited a well-developing blood vessel network into the islet engrafts. Thus, an SF sponge disc was successively available as the cryodevice for islet vitrification, the transporter of the angiogenic VEGF, and the scaffold for subrenal transplantation in the rat model.

Fabrication of functional rat pseudo-islets after cryopreservation of pancreatic islets or dispersed islet cells.

Dispersed single cells from pancreatic islets can configure the three-dimensional islet-like architecture (pseudo-islets) with insulin secretion potential and controllable size through their aggregation property. The present study was designed to investigate whether cryopreservation of islets or islet cells can contribute to the efficient pseudo-islet fabrication in the rat model. In control group (CT), islet single cells were prepared by trypsin digestion of 50-400-µm ø fresh control islets, and then cultured for 3 days in the U-bottom microwell to fabricate pseudo-islets. In vitrification-warming group (VW), islet single cells were prepared from postwarm islets cryopreserved by vitrification on nylon mesh device, and then cultured for 3 days. In freezing group (FR), islet single cells originated from fresh islets were subjected to a conventional Bicell® freezing, and postthaw cells were cultured for 3 days. To generate 1 islet equivalent pseudo-islets (150 µm ø) by the sphere culture, 1250 CT cells, 1250 VW cells, and 1500 FR cells were seeded to each microwell. The viability of the pseudo-islets was comparable among the three groups (93.9%-96.9%). Furthermore, the insulin secretion assay showed that those pseudo-islets responded sufficiently to the high glucose stimulation. Immunostaining for insulin and glucagon showed that the endocrine cell arrangement of those pseudo-islets is similar to that of native and isolated islets. These islets/pseudo-islets had the ß-cells in core and the α-cells in mantle, which was typical characteristic of the rodent islets. However, some clusters of α-cells were observed inside the FR pseudo-islets. Interestingly, the VW pseudo-islets had significantly fewer α-cells than the CT or FR pseudo-islets. These results suggest that the sphere culture of islet cells is useful tool to generate the pseudo-islets with the customized size and normal functionality, even after islet cryopreservation.

Acellular matrix derived from rat liver improves the functionality of rat pancreatic islets before or after vitrification.

Cryopreservation of pancreatic islets can overcome the severe shortage of islet donors in clinical islet transplantation, but the impaired quality of post-warm islets need improvement. This present study was conducted to investigate whether the pre- or post-treatment of rat islets with liver decellularized matrix (LDM) for vitrification can improve the viability (FDA/PI double staining) and the functionality (glucose-stimulated insulin secretion [GSIS] assay). Rat LDM was prepared by high-hydrostatic pressure, lyophilization, and re-suspension in saline. Co-culturing of isolated islets with 0 (control), 30, 60, or 90 µg/ml LDM for 24 h resulted in the comparable viability among the 4 groups (98.7-99.6%) and the higher insulin secretion potential in 30 and 60 µg/ml LDM treatment groups than the control group (stimulation index [SI]: 12.1 and 12.7, respectively, vs. 6.5 in the control group, P < 0.05). When the islets co-cultured with 60 µg/ml LDM were vitrified-warmed on a nylon mesh cryodevice, the viability and the GSIS of the post-warm islets were not improved. Post-treatment of vitrified-warmed islets with 60 µg/ml LDM during the recovery culture for 12 h resulted in the comparable clearance of degenerating cell debris from the post-warm islets, while their insulin secretion potential was improved (SI: 5.0 vs. 3.5 in the control group, P < 0.05). These findings indicate that the components in LDM can enhance the insulin secretion potential of rat islets suffering damage by enzymatic stress during the islet isolation process or by cryoinjuries during the vitrification-warming process.

Transplantation of rat pancreatic islets vitrified-warmed on the nylon mesh device and the silk fibroin sponge disc.

We report the adaptability of rat islets vitrified-warmed on nylon mesh (NM) device or silk fibroin (SF) sponge disc for the normalization of the blood glucose level in rat models of diabetes. One-hundred rat islets were cryopreserved according to a minimum volume cooling protocol on an NM device or a solid surface vitrification protocol on an SF sponge disc. The recovery rate (97.1% vs. 93.8%), the viability (77.9% vs. 74.4%), and the stimulation index (4.7 vs. 4.2) in glucose-stimulated insulin secretion (GSIS) assay of the post-warm islets were comparable between the NM vitrification and the SF vitrification groups. The viability and the stimulation index of the fresh control islets were identified to be 97.5% and 6.5, respectively. Eight hundred islets from the NM or the SF vitrification group or the fresh control group were transplanted beneath the kidney capsule of a streptozotocin-induced diabetic rat (blood glucose level > 350 mg/dl). Within 3 weeks after transplantation, the acquisition of euglycemia (< 200 mg/dl) was observed in recipient rats (80.0-83.3%). An intraperitoneal glucose tolerance test on Day-30 and Day-60 showed similar 2-h responses to the glucose uptake of cured rats among the compared groups. Moreover, the successful engraftment of transplants was confirmed by the Day-70 nephrectomy through the subsequent diabetes reversal and histological evaluation. Thus, large quantities of rat islets vitrified-warmed on an NM device or an SF sponge disc were proven to be fully functional both in vitro and in vivo, due to the GSIS and syngeneic transplantation, respectively.